SuperATV Recalls Carrier Bearings for Polaris RZR XP and Turbo S Recreational Off Highway Vehicles Due to Fire and Burn Hazards

Official action

Source. US Consumer Product Safety Commission

Official identifier. 25-150

Date. 2025-02-20

Jurisdiction. United States

Hazard (official). When the recalled carrier bearings are installed in a Polaris RZR XP Turbo or Turbo S vehicle and the fuel tank expands, the drive shaft can come in contact with the fuel tank, causing the tank to develop a hole or crack. This can cause the fuel tank to leak gasoline, posing fire and burn hazards.

Action / remedy (official). Consumers should immediately stop using ROVs with the recalled carrier bearings, remove them from the Polaris RZR XP Turbo or Turbo S vehicles, and register online at https://form.jotform.com/243023918871055 to receive a postage-paid label to return the recalled bearings. SuperATV will mail consumers free replacement carrier bearings upon receipt of the recalled carrier bearings. SuperATV is notifying all known purchasers directly. No purchase receipt is required.

Product. SuperATV carrier bearings for Polaris RZR XP Turbo or Turbo S Recreational Off Highway Vehicles (ROVs)

Identification details. This recall involves three models of SuperATV carrier bearings sold from April 2017 until September 2022 for installation in Polaris RZR XP Turbo or Turbo S vehicles. The recalled carrier bearings are silver and black and have “SuperATV” etched on top of the carrier bearing housing. The carrier bearing is located under the center console tunnel which is behind the seats on the two-seat model and behind the rear seats on the four-seat models. The following carrier bearing models are subject to this recall if purchased for the Polaris RZR XP Turbo or Turbo S vehicles in the identified date ranges:RECALLED CARRIER BEARING MODELPOLARIS RZR XP TURBO OR TURBO SPURCHASE DATE RANGEBEA01-0014/13/17 through 4/27/19BEA01-0025/19/18 through 1/22/19BEA01-005 (Rev A00 and A01)1/25/19 through 9/2/22

Units. About 10,700

Incidents reported by CPSC. SuperATV has received 24 reports of the fuel tank contacting the prop shaft, including 19 reports that a hole or crack had formed in the fuel tank, including one reported fire. No injuries have been reported.

Remedy type. Replace

Sold at. Online at www.superatv.com and at off-road vehicle dealers nationwide from April 2017 until September 2022 for between $85 and $250 (for one carrier bearing) and between $170 and $420 (set of 2 carrier bearings).

Official record

Licence: US Government recall data made available for business and application reuse

Attribution: Source: U.S. Consumer Product Safety Commission recall notice